Briggs & Stratton 610000 Specifiche Pagina 75
- Pagina / 191
- Indice
- RISOLUZIONE PROBLEMI
- SEGNALIBRI
Valutato. / 5. Basato su recensioni clienti
3
74
Fig. 24
Fig. 25
Remove Camshaft
1. Remove governor spool (8) from camshaft (7),
Fig. 26. Discard gasket and O-ring.
2. Rotate crankshaft and camshaft until timing
marks (9) align. Remove camshaft.
3. Remove tappets.
Fig. 26
Remove Pistons and Connecting Rods
NOTE: Remove any carbon or ridge at the top of
cylinder bores to prevent breaking rings
when removing piston and connecting rod
assemblies.
1. Remove #2 connecting rod cap.
2. Push connecting rod and piston assembly (11)
out of #2 cylinder (arrow), Fig. 27. Reassemble
cap to rod to prevent interchanging.
3. Repeat for #1 cylinder (10).
Fig. 27
11
Remove Crankshaft
Remove crankshaft (1) from cylinder, Fig. 28.
Fig. 28
AFTER DISASSEMBLY
• Remove gasket material from ALL surfaces.
• Remove oil seals.
• Thoroughly clean parts in solvent.
• Organize all components. Keep parts that are
assemblies together.
For Briggs & Stratton Discount Parts Call 606-678-9623 or 606-561-4983
www.mymowerparts.com
- Section 1 2
- ( ) is used to identify 3
- BEFORE PERFORMING ADJUSTMENTS 4
- OR REPAIRS 4
- WHEN TESTING FOR SPARK 4
- Additional Precautions 6
- Revised 4/04 7
- Fuel Recommendations 8
- Oil Recommendations 9
- AIR CLEANER SERVICE 10
- Round Air Cleaner 10
- Square Air Cleaner 11
- Cyclonic Air Cleaner 11
- ARMATURE AIR GAP ADJUSTMENT 12
- CARBURETOR ADJUSTMENTS 12
- 1938919200 13
- Choke Control Adjustment 17
- Combustion Chamber Deposits 17
- Cooling System Cleaning 17
- Crankcase Oil 18
- Governor Adjustments 19
- 50 RPM 22
- Oil Cooler 23
- Spark Plugs 23
- Speed Control Wire Adjustment 24
- Valve Clearance Adjustment 24
- TUNE-UP PROCEDURE 25
- OVERHAUL PROCEDURE 25
- Inspection and Repairs 26
- Reassemble 26
- Section 2 28
- Troubleshooting 28
- SYSTEMATIC CHECK 29
- Ignition 29
- Carburetion 30
- Compression 30
- ELECTRICAL SYSTEMS 33
- Alternators 33
- Testing Alternator Output 36
- ))) (DIODE TEST) position 37
- POWERLINKt SYSTEM 46
- Anti-Afterfire Solenoid 48
- Testing Battery 49
- Testing Engine Wiring Harness 51
- harness at solenoid 52
- Oil Pressure 54
- KEY SWITCH 56
- Starter Motor 57
- ))) (DIODE TEST) 58
- Governor Test 60
- – (NEGATIVE, 3) to GREEN 60
- Replacing Actuator 60
- GASEOUS FUELED ENGINES 62
- GASEOUS FUEL CARBURETOR 64
- ADJUSTMENT 64
- LPG-Only Operation 64
- Section 3 66
- Engine Disassembly 66
- ENGINE DISASSEMBLY 69
- Preparation 69
- Remove Air Cleaner Assembly 69
- Remove Blower Housing and Fan 70
- Remove Control Bracket 71
- Remove Armatures 71
- Remove Flywheel 72
- Remove Oil Pump 74
- Remove Camshaft 75
- Remove Crankshaft 75
- AFTER DISASSEMBLY 75
- Section 4 76
- Fuel Systems and Carburetion 76
- FUEL SYSTEMS 77
- 7 Quart Fuel Tank 77
- 9 Quart Fuel Tank 78
- Fuel Pump 79
- Fuel Filter 80
- Fuel Shut-Off Valve 80
- CARBURETION 80
- Carburetor Identification 80
- Carburetor Removal 80
- Carburetor Service 82
- Section 5 114
- Governor 114
- Models 540000, 610000 118
- Section 6 120
- Cylinder Heads and Valves 120
- PARTS IDENTIFICATION 121
- CYLINDER HEAD SERVICE 121
- Remove Cylinder Head 121
- Disassembly 122
- Inspect and Repair 122
- ASSEMBLY 124
- Install Cylinder Heads 125
- Install Rocker Arms 125
- Install Push Rods 125
- Section 7 126
- Starters 126
- GENERAL INFORMATION 127
- Nylon Pinion 127
- Steel Pinion 127
- Solenoid Shift 127
- STARTER DRIVE SERVICE 127
- C-Ring Style 128
- Roll Pin Style 128
- Steel Pinion Style 129
- STARTER MOTOR SERVICE 129
- Disassemble 129
- Inspect Armature Commutator 130
- Inspect Brushes 130
- Replace Brushes 131
- Assemble End Cap 131
- Assemble Armature 132
- Assemble Housing 132
- Install Drive End Cap 133
- Remove Starter Solenoid 133
- Install Starter Solenoid 133
- Pinion Gear 134
- (27.0 MM) 135
- RING GEAR SERVICE 137
- REWIND STARTER IDENTIFICATION 138
- REWIND STARTER SERVICE 138
- Remove Rewind Starter 138
- Replace Rope 139
- Replace Pulley and Spring 140
- Install Rewind Starter 143
- Section 8 144
- Lubrication Systems 144
- Oil Pump 148
- Oil Fill Tube and Dipstick 148
- Section 9 150
- CYLINDERS 151
- Inspect and Measure 151
- Resizing Cylinder 151
- Finishing 152
- Cleaning 152
- ENGINE BEARINGS 153
- Mag Bearing – After 970430xx 153
- Mag Bearing – Before 970501xx 153
- PTO Ball Bearing 154
- PTO Plain Bearing 155
- Oil Seal 155
- Camshaft Bearings 155
- Section 10 156
- Crankshafts and Camshafts 156
- INSPECT CRANKSHAFT 157
- INSPECT FLYWHEEL 157
- INSPECT CAMSHAFT 158
- Section 11 160
- Fig. 5. Replace piston if 162
- Section 12 164
- Engine Assembly 164
- ENGINE ASSEMBLY 165
- Install Crankshaft 165
- Install Camshaft 165
- Install Oil Pump 166
- Install Flywheel 168
- Torque Flywheel Nut 168
- Install Fan 169
- Install Flywheel – 169
- Engines with PowerLinkt 169
- Install Armatures 170
- Install Control Bracket 170
- Install Blower Housing 173
- Install Air Cleaner 173
- Final Engine Assembly 176
- Static Governor Adjustment 176
- Section 13 178
- Engine Specifications 178
- Models 290000, 300000 179
- Torque Values 180
- Description Torque 180
- Model 350000 181
- Model 380000 183
- Starter Motor Support Block 188
- Starter Motor Test Bracket 188
Prodotti e manuali riguardandi Accessori e componenti per motoveicoli Briggs & Stratton 610000
Accessori e componenti per motoveicoli Briggs & Stratton Sprint 90000 Manuale dell'Operatore
(20 pagine)
(20 pagine)
Accessori e componenti per motoveicoli Briggs & Stratton 124600 Istruzioni per gli Interventi
(20 pagine)
(20 pagine)
Accessori e componenti per motoveicoli Briggs & Stratton 030212 Manuale del Proprietario
(16 pagine)
(16 pagine)
Accessori e componenti per motoveicoli Briggs & Stratton 250000 Manuale del Proprietario
(20 pagine)
(20 pagine)
Accessori e componenti per motoveicoli Briggs & Stratton 460000 Manuale del Proprietario
(20 pagine)
(20 pagine)
Accessori e componenti per motoveicoli Briggs & Stratton 589447 Istruzioni per gli Interventi
(20 pagine)
(20 pagine)
Accessori e componenti per motoveicoli Briggs & Stratton PROFESSIONAL SERIES 140000 Manuale dell'Operatore
(28 pagine)
(28 pagine)
(12 pagine)
(10 pagine)© 2020, manymanuals.it. Tutti i diritti riservati | 0.035 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Commenti su questo manuale